Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Specifications

Generator Set Specifications

Maximum Rating
800 ekW
Minimum Rating
635 ekW
Emissions/Fuel Strategy
Low Fuel Consumption
Voltage
220 to 480 Volts
Frequency
60 Hz
Speed
1800 rpm
Duty Cycle
Standby, Prime

Engine Specifications

Engine Model
3412C TA, V-12, 4-Stroke Water-Cooled Diesel
Bore
5.4in
Stroke
6in
Displacement
1648.86in³
Compression Ratio
13:00:01
Aspiration
TA
Fuel System
Pump and Lines
Governor Type
ADEMâ„¢ A5

Generator Set Dimensions

Length - Maximum
162.4in
Width - Maximum
78.3in
Height - Maximum
75in
Dry Weight - Genset (minimum)
5761lb
Dry Weight - Genset (maximum)
13275lb

Standard/Optional Features

Standard Equipment:

  • Air Inlet System
    • Air cleaner, single element canister type
    • Single element canister type
  • Control Panel
    • High coolant temperature
    • Customer data link (Modbus RTU)
    • Low coolant temperature
    • Low coolant level
    • Communications:
    • Run/auto/ stop/control
    • Engine cycle crank
    • Generator temperature monitoring module
    • Power factor (per phase & average)
    • Remote CAN annunciator
    • Serial annunciator module data link
    • DC volts
    • Frequency (Hz)
    • Operating hours.
    • Emergency stop pushbutton
    • Digital I/O module
    • Local annunciator
    • Low oil pressure
    • Oil pressure (psi, kPa or bar)
    • Emergency stop
    • Warning shutdowns:
    • Volts (L-L & L-N)
    • Remote Serial annunciator
    • Speed adjust
    • Amps (per phase & average)
    • Voltage adjust
    • EMCP 4.2B
    • Overspeed
    • coolant temperature
    • Digital Indicator for:
    • RPM
    • Accessory module data link
    • Failure to start (overcrank)
    • Controls:
    • Compatible with the following optional modules:
  • Cooling System
    • Caterpillar extended life coolant
    • Radiator with guard (sized for 50 degrees C)
    • Fan and belt guards
    • Coolant drain line with valve
  • Exhaust System
    • Stainless steel exhaust flex with ANSI style outlet flange
  • Fuel System
    • Primary and Secondary fuel filters
    • Fuel priming pump
    • Water separator
  • Generator And Attachments
    • 3 Phase sensing
    • SR4B self excited
    • Class F temperature rise
    • VR6B voltage regulator
    • Busbar termination
    • 12 Leads
    • Class H insulation
    • 2:1 Volts/Hz
    • Reactive droop
  • Governing System
    • Cat electronic governor
  • Lube System
    • Oil drain line with valve
    • Lubricating oil
    • Oil filter
  • Mounting System
    • Base, formed steel with linear vibration isolators between base and engine-generator
  • Starting / Charging System
    • Battery with rack, cables
    • 45 Amp Charging alternator
    • Fuel shutoff solenoid
    • 24 Volt starting motor
  • General
    • Paint - Caterpillar yellow except rails and radiators gloss black

Optional Equipment:

  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
  • Air Inlet System
    • Air cleaner - Dual element
    • Air cleaner - Heavy element
    • Air cleaner - single element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 4 Pole Circuit breakerswith shunt trip
    • 3 Pole Circuit breakers with shunt trip
    • Power terminal strip
  • Control Panel
    • EMCP 4.3, EMCP 4.4
    • Temperature monitoring package
    • Vandal proof panel door
    • Generator running VFC
    • Earth leakage Ground fault relay
    • Common alarm/shutdown relay
  • Cooling System
    • Jacket water heater
    • Radiator duct flange
    • Radiator removal
  • Exhaust System
    • Muffler 10 dBA attenuation
    • Manifold and turbocharger guards
    • Muffler 35 dBA attenuation
    • Elbow mounting kit
    • Through wall installation kit
  • Fuel System
    • Manual fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Internal excitation (IE)
    • Anti-condensation heater
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
    • Fuel tank base (1200 Ltr)
  • Special Tests / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Oversize battery set
    • Battery chargers
    • Heavy duty starting system
    • Battery disconnect switch
    • Battery removal
  • Enclosures
    • DC lighting package
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)

Contact N C Machinery today for all of your equipment needs!

Contact Us